Home  | Company  |  Support  |  Business Login  |  Contact  
Articles and Videos

Refrigeration Systems

This Homershams article begins with a brief description of the operation of a refrigeration system, and then in section 2 we examine some products that Homershams stock that are relevant to the industry.

Section 1:  Basic Principles of Operation

Circulation 400 The vast majority of refrigeration systems work on the compression system.  This compressive system works because of three physical properties. 
  1.  A liquid will evaporate (i.e. boil) at much lower temperatures if the pressure is low (e.g. water boils at 70 °C in the Himalayas) 
  2.  When an object changes from liquid to gas or gas to liquid, heat is absorbed or released 
  3. The “Fist law of Thermodynamics” states that energy is never lost; just changed from different states to different states. 
In a typical refrigeration system, heat from food causes a refrigerant at low pressure to evaporate (remember low pressure = low boiling point) and hence absorbs this heat.  The now gaseous refrigerant is then compressed to a high pressure and then gives off its heat in the condenser.

Now one of the most misunderstood items in this system is the Thermostatic Expansion Valve (see Honeywell TEV below in section 2).  The TEV is a pressure reducing valve, moving the refrigerant pressure from high to low in a controlled fashion and in response to system temperature.

TEV’s are used in commercial systems, whereas domestic refrigerators (for example) use a simple capillary tube (fixed orifice) to perform this task.
Fridge 200 Refrigeration 200

An odd, special use fridge is the gas-powered camping type.  It may seem counter-intuitive to think of burning gas to make refrigeration, but it works on a similar principle to the compression fridge.  In this case the refrigerant (Ammonia) is dissolved in water.  When the water/ammonia mix is heated the ammonia is released as gas and hence begins the cycle as described previously.

Refrigerant Gases 
Many different gases may be used as refrigerants.  Their rate of volatility (i.e. how quickly they will evaporate) greatly affects their relative effectiveness.  A more volatile gas will more quickly evaporate, and hence remove heat.  Ammonia and ether were early examples. Examining the boiling points of various refrigerants is an interesting exercise.  For example the boiling point of R-23 is -82 °C!   Thinking about the nature of volatile gases it’s not hard to imagine the dangers that might be associated with some of these.  The tragic Tamihere cold store fire of 2008 is a timely reminder of this. 
Other chemicals such as Freon many be used, but Freon is a well-known ozone destroyer, so has ecological impact.  Ammonia remains a powerful and useful refrigerant, but can be unpopular with the public due to perceived danger despite the fact that it’s main public complaint is odour, which is also its greatest warning, as it’s detectable in miniscule parts-per-million (or even parts per billion) levels .  One of the recommendations from the inquiry into the Tamihere cold store fire, was that “stenching agents” (smell) be added to any refrigerant gas to make their detection easier.
ASHRAE(American Society of Heating, Refrigerating and Air Conditioning Engineers) give part numbers to the many different types of refrigerant gas.  A couple of examples are shown below
R-717                                     Ammonia
R-744                                     Carbon Dioxide
R -134 aka HFC-134a           Ozone depleting “Freon” type
R-22                                       ODP used at Tamihere before changing to R290
R290/R170                             HyChill Minur 50 as used at Icepack Tamihere (Propane and a little ethane)
A complete list is published in several places, but Wikipedia’s list is good and fairly concise

Enthalpy A thermodynamic quantity equivalent to the total heat content of a system. It is equal to the internal energy of the system plus the product of pressure and volume
Latent Heat of Evaporation The amount of energy needed to be added to a system to change state from liquid to vapor without a change in the liquids temperature
Latent Heat of Condensation The energy given off by a vapour condensing to a liquid
Superheat The extra energy absorbed by the vapour.  Remember we said that R23 boils at -82 °C? Well if we heat R23 it to 3 °C, it now contains 85 degrees of superheat available for use.

 Report on the Tamihere Coolstore disaster.  

Section 2:  Products Related to Refrigeration

Click on the picture below to go to the product page
0000001968356 Honeywell Thermostatic Expansion Valves (previously known as Flica)
0000001679760 Center 382 Refrigerant Leak Detector is useful for finding leaks in a system
0000002241384 Teltherm 3063REF Refrigeration Pressure Gauge
0000000000971 Dwyer Flow Switches are designed to provide inexpensive, reliable monitoring of the presence or absence of flow in a system.
The V10 series is available for field installation in pipelines from 1/2 to 2" diameter and available in brass or 303 SS body. 
0000000000978 The V8 series is available for installation in a 1 to 6" pipe with operating pressures are up to 150 psig (10 bar) and temperatures to 100 °C.
0000000000820 Center 309 Datalogger for checking temperatures of fridges & heat pumps

Homersham’s are 100% NZ Owned and have been supporting New Zealand business for over 75 years
s1Guarantee s1Delivery s1Security s1Feedback &
s1Technical Help VideoVideos &

Monthly Newsletter is no longer being published. check out our LinkedIn profile for updates

Past Newsletter Articles


Be secure with Homersham’s

IANZ 2020 155x71
btn more

Contact Us

Ph 03 358 8309
Fax 03 963 2016

3 Homersham Place, Burnside
Christchurch 8053
New Zealand

Join Us